环境卫生工程 ›› 0, Vol. ›› Issue (): 0-.

• •    下一篇

对生活垃圾焚烧炉掺烧市政污泥所产生飞灰的螯合稳定化实验研究

  

  1. 上海康恒环境股份有限公司
  • 收稿日期:2021-12-29 修回日期:2022-02-10 接受日期:2022-05-07 发布日期:2025-03-03

Experimental Study on Fly Ash stabilization of MSWI co-Incineration of Municipal Sludge

  1. Shanghai SUS Environment Co. Ltd.
  • Received:2021-12-29 Revised:2022-02-10 Accepted:2022-05-07 Published:2025-03-03

摘要:

以国内某垃圾焚烧电厂炉排炉掺烧市政污泥产生的飞灰作为实验样本,对掺烧污泥产生飞灰的重金属总量与浸出特性进行了分析比较。结果表明,与零掺烧相比,掺烧市政污泥虽然减少了飞灰中重金属的总量,但污泥掺烧产生的SOx消耗了碱性药剂使得飞灰的残留碱度明显下降,相应浸出pH低至5.27,Pb、Cd等重金属浸出浓度远高于GB 16889限值。对掺烧污泥产生的飞灰添加10%的消石灰,可提高飞灰残留碱度,浸出pH提高至6.32,Pb、Zn、Cd、As浸出浓度低于GB 16889。因此在掺烧污泥的同时对烟气净化系统的脱酸药剂加量进行灵活调整,对提高飞灰浸出稳定性有着积极作用。

关键词: 垃圾焚烧, 污泥协同掺烧, 飞灰, 重金属浸出

Abstract:

The fly ash from a MSWI co-incineration of municipal sludge was analyzed to compare the heavy metal content and leaching characteristics. The results showed that co-incineration of municipal sludge reduced the total amount of heavy metals in fly ash..While the SOx generated by sludge blending consumes alkaline reagents, which significantly reduces the residual alkalinity of fly ash, leading to the low leaching pH of 5.27. The corresponding leaching concentration of heavy metals such as Pb and Cd was much higher than the limits of GB 16889.Addition of 10% limestone into fly ash increased the residual alkalinity, indicated by a higher leaching pH of 6.32 and lower leaching concentration of Pb、Zn、Cd、As than the limits of GB 16889. While mixing the sludge, the amount of deacidification agent feed into the flue gas purification systemis suggested to be flexibly adjusted, which would contribute to the heavy metal stability of fly ash. 

Key words: Waste incineration, co-incineration of sludge, fly ash, the leaching of heavy metal

[1] 段飞飞, 朱传强, 杨 林, 扈明东, 尹晓龙, 韩 昊. 大容量垃圾焚烧炉内脱硫脱硝一体化工艺研究[J]. 环境卫生工程, 2024, 32(6): 64-69.
[2] 龚 越. 面向垃圾焚烧余热锅炉受热面的超频震波清灰技术应用与研究[J]. 环境卫生工程, 2024, 32(6): 74-79.
[3] 甘 洁, 刘 豪, 李建辉. 国内外生活垃圾焚烧厂的水排放与监管标准比较分析[J]. 环境卫生工程, 2024, 32(5): 11-16.
[4] 余亚萍. 污泥焚烧烟气脱酸工艺技术经济分析[J]. 环境卫生工程, 2024, 32(5): 87-92.
[5] 吕烨佳, 张 佳, 岳 阳, 钱光人. 焚烧飞灰深度资源化技术进展及展望(封面文章)[J]. 环境卫生工程, 2024, 32(4): 1-8.
[6] 田 伟, 陈 琮, 彭 莉, 陈玉成. 垃圾焚烧飞灰及其固化/稳定化产物的重金属污染特征及环境风险评估[J]. 环境卫生工程, 2024, 32(4): 9-16.
[7] 陈 璐, 杨德坤, 龙吉生. 一体化烟气净化工艺对生活垃圾焚烧厂多污染物协同脱除特性的研究[J]. 环境卫生工程, 2024, 32(4): 51-57.
[8] 王延涛, 龙吉生, 秦 峰. 生活垃圾焚烧发电厂设计参数与焚烧负荷变化的统计分析[J]. 环境卫生工程, 2024, 32(4): 58-62,71.
[9] 黄 华, 黄正鹏, 沈元鹏, 李 浓. 生活垃圾焚烧厂渗滤液全量化处理技术研究[J]. 环境卫生工程, 2024, 32(4): 78-82.
[10] 邹 昕. 中国垃圾焚烧标准回顾与分析(封底文章))[J]. 环境卫生工程, 2024, 32(4): 97-104,111.
[11] 段盼巧, 刘晶昊, 白良成. 生活垃圾焚烧项目可靠性评价分析[J]. 环境卫生工程, 2024, 32(4): 112-116.
[12] 李俊成, 毛梦梅, 龙吉生. 掺烧污泥对垃圾焚烧发电厂烟气净化系统的影响——以某污泥协同焚烧项目为例[J]. 环境卫生工程, 2024, 32(3): 54-58.
[13] 陈海军, 许 睿, 赵景才, 龙吉生. 垃圾焚烧发电厂变频给水泵运行改造节能分析[J]. 环境卫生工程, 2024, 32(3): 59-63.
[14] 邱清文. 填埋场生活垃圾焚烧飞灰的土力学特性[J]. 环境卫生工程, 2024, 32(3): 84-89.
[15] 邓飞飞, 张栋棚, 郑仁栋, 周纬南, 吴迪迪, 吕媛媛. 杭州市生活垃圾焚烧厂渗滤液季节性变化特征研究[J]. 环境卫生工程, 2024, 32(3): 90-93.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 天津市城市管理研究中心
津ICP备2022007900号-1   津公网安备 12010302000952号   中央网信办违法和不良信息举报中心
地址:天津市河西区围堤道107号    邮政编码: 300201
电话: 022-28365069 传真: 022-28365080 E-mail: csglwyjs10@tj.gov.cn
本系统由北京玛格泰克科技发展有限公司设计开发